|
1)
Every vehicle needs to be prepared properly to enjoy a long and satisfying
life. We professionally and completely prepare the entire surface, inspecting
and correcting the door gaps, the boot and bonnet lines. Even under the
bonnet and inside the boot gets our close attention. When we are completely
happy with the end result, the final colour coats are applied.
Afterwards we spray a tough and resilient coating to the whole under body
for long lasting protection and the chassis sections are independently
Waxoyled giving the vehicle a total inside and out protective coating
that will last for years to come. A new wiring harness is carefully installed.
|
|
2) All new brake discs are fitted along with re-conditioned callipers,
pads and shoes. New copper brake pipes and flexible pipes are installed
and are complemented by a new brake master cylinder and new rear wheel cylinders.
The clutch master cylinder is also new, along with the clutch slave cylinder
and associated pipework.
The reconditioned kingpins are assembled to the cross member with re-conditioned
shock absorbers and the new steering rack is complete with track rod ends.
All new bushes are used along with new lower suspension pans. New link bars
and rear axle straps are fitted and a new fuel tank and sender unit is installed.
|
|
|
3)
The engine and gearbox are fully re-conditioned, along with re-conditioned
Carburettors and distributor. The rear axle is re-conditioned and new springs
and U-bolts are fitted as well as new rubber mounting bushes. A new exhaust
system is fitted from the Manifold to the tail pipe with all new flexible
rubber mountings. A re-conditioned alternator, fan belt and starter is fitted,
new air and oil filters are installed with, of course, fresh oil. New clutch
pressure plate, friction plate and release bearing are fitted. The engine
and gearbox sits on new flexible mountings and is connected to a new radiator
by new rubber hoses. The propshaft is fitted with new Universal joints.
A new water pump is fitted together with a new thermostat. New clips and
fuel hoses are fitted and a new fuel pump feeds through a new fuel filter.
A new battery is fitted together with new battery connectors and a new earth
lead to both the battery and the engine itself. |
4) The car benefits from new front and rear bumpers, over-riders, bumper
fitting kit, new number plate lights, new front grille and new fresh air
duct cover. New stainless steel trims are fitted to the sides as well as
new sealed beam headlight units, new headlight rims, headlamp assemblies
and seals. Wiper blades and arms, fuel filter cap, door locks and gear lever
knob are all fitted new and are followed by five wire wheels and new tyres.
|
| 5)
The interior is now lavished with care and attention. The carpet sections
are carefully applied to floor and tunnel sections, the quarter lights are
fitted with new rubber seals and a new windscreen laminated glass is fitted
along with new surround and base seal. Two 'P' strips are fitted to the
windscreen frame, the doors are assembled and fitted with new panels as
are the front and rear sides and back section. A new crash pad is fitted,
as well as new furflex inner door linings. The dashboard is assembled and
new heater control cables are fitted with a new indicator switch. A new
speedometer cable is installed together with a new steering wheel. New fully
retractable seat belts are fitted along with armrests, hood tenax fittings
and a new hood and frame. The doors are assembled and finished with new
door cappings. |
|
6) The whole car is now checked and re-checked and final adjustments
are made before an independent inspection is carried out by a respected
professional engineer. The vehicle is then presented to the Ministry of
Transport Testing Authority for the final examination before registration
and road testing begins.
After all this has been carried out and a multitude of minor adjustments,
tests and verification procedures have been undertaken, the owner is presented
with the keys, a photographic history of the assembly, a 12 month warranty
and a 12 month recovery scheme. A jack and wheel brace are placed in the
boot and the hand over and explanations of living with a beautiful MG now
begin.
|
|
|
|
